BodyworkMedium
Load area, sill and side-door damage from working use
Body & corrosion repair£250–£1,800
Inspect · Inspect the load floor, side door runners and sills
2019–2026 Toyota Proace City · common fault repair costs
What the known faults on this Toyota Proace City typically cost to put right at a UK independent garage · use the figures to price risk before you bid, and to justify a reduction when something shows up on inspection.
Cost at a glance
- Most expensive fault
- £250–£1,800
- Top three risks, from
- £1,200
- Worst case, everything
- £10,400
The single priciest documented job on the 2019–2026 Toyota Proace City is body & corrosion repair at £250–£1,800. Few cars need every repair listed here · treat £2,390–£10,400 as the full exposure if one arrived with all of them.
Cost per fault
EngineHigh
1.5 BlueHDi DPF and AdBlue faults on short-run vans
DPF forced regen or replacement£250–£1,600
Inspect · Check for AdBlue warnings and completed regenerations
TransmissionLow
Stiff or notchy manual gear selection, particularly when shifting into first or second gear, caused by stretched or dry selector cables.
Clutch & dual-mass flywheel£700–£1,600
Inspect · With the engine off, depress the clutch and cycle rapidly through all gears. Excessive resistance or a rubbery, obstructive feel indicates linkage or cable wear.
Interior / InfotainmentMedium
Touchscreen freezes, reboots randomly, or remains blank on start-up due to software or head unit failure.
Infotainment repair or software fix£120–£1,200
Inspect · Start the engine, engage reverse to trigger the parking sensors or camera, then rapidly tap through the media and settings menus to check for system lag or crashing.
EngineHigh
1.2 PureTech petrol wet cambelt degradation
Timing / wet belt kit + water pump£450–£1,100
Inspect · Ask for wet-belt replacement records and inspect the oil
SuspensionMedium
Rear suspension sagging on regularly loaded vans
Suspension refresh (per axle)£250–£1,100
Inspect · Check ride height and rear bump-stop contact
Steering / SuspensionMedium
Creaking, groaning, or spring-binding noises from the front end when turning at low speeds due to water ingress in the MacPherson strut top mount bearings.
Suspension refresh (per axle)£250–£1,100
Inspect · With the engine running and the van stationary, turn the steering wheel fully from lock to lock while listening outside with the windows down for top mount noise.
ElectricalLow
Rear door and bulkhead wiring faults
Electrical diagnosis & module repair£120–£900
Inspect · Test every light and rear-door switch
Ranges are indicative parts-and-labour costs at a UK independent garage, inclusive of VAT. Franchised dealers typically sit 40–80% higher, and prestige or electrified variants sit at the top of each band. Always get a written quote before committing.
Inspecting a Toyota Proace City this week?
Build a tickable checklist for the exact car in front of you, record faults with photos, and hand the buyer a report.