BodyworkMedium
Rust around rear door hinges and load area floor
Body & corrosion repair£250–£1,800
Inspect · Inspect rear doors, sills and load floor for corrosion
FI
2016–2024 Fiat Talento · common fault repair costs
What the known faults on this Fiat Talento typically cost to put right at a UK independent garage · use the figures to price risk before you bid, and to justify a reduction when something shows up on inspection.
Cost at a glance
- Most expensive fault
- £250–£1,800
- Top three risks, from
- £750
- Worst case, everything
- £10,200
The single priciest documented job on the 2016–2024 Fiat Talento is body & corrosion repair at £250–£1,800. Few cars need every repair listed here · treat £2,270–£10,200 as the full exposure if one arrived with all of them.
Cost per fault
BodyworkMedium
Side sliding door dropping, jamming, or scraping the bodywork due to collapsed bearings in the middle or lower runner assemblies.
Body & corrosion repair£250–£1,800
Inspect · Open and close the sliding doors fully. Listen for grinding noises and check the painted sill area for fresh metal scoring where a dropped door has dragged.
EngineHigh
1.6 and 2.0 dCi turbo and DPF issues on stop-start work
DPF forced regen or replacement£250–£1,600
Inspect · Check for smoke on acceleration and confirm DPF regen completes on a run
TransmissionMedium
Clutch wear on vans used for heavy loads
Clutch & dual-mass flywheel£700–£1,600
Inspect · Feel for slip under load pulling away on an incline
SuspensionMedium
Front suspension bush wear from overloaded running
Suspension refresh (per axle)£250–£1,100
Inspect · Check for knocking over bumps and uneven front tyre wear
EngineHigh
Coolant loss or rough idling caused by a cracked EGR cooler or heavily carbon-fouled EGR valve on the 1.6 EcoJet engines.
EGR valve / cooler replacement£300–£900
Inspect · Check the coolant expansion tank for low fluid or soot mixing. Start the engine from cold and listen for a hunting idle or hesitation when blipping the throttle.
ElectricalMedium
Instrument cluster and warning light faults
Diagnostics & follow-on repair£90–£700
Inspect · Check all dash warning lights extinguish correctly after start-up
TransmissionMedium
Stiff gear selection or inability to engage first and second gears due to stretched or binding gear selector cables.
Routine repair£180–£700
Inspect · With the engine off, cycle the gear stick through all gears rapidly. Feel for excessive resistance, sloppiness, or a failure to securely notch into first and second.
Ranges are indicative parts-and-labour costs at a UK independent garage, inclusive of VAT. Franchised dealers typically sit 40–80% higher, and prestige or electrified variants sit at the top of each band. Always get a written quote before committing.
Inspecting a Fiat Talento this week?
Build a tickable checklist for the exact car in front of you, record faults with photos, and hand the buyer a report.